How much do you think it will be to finish off this project? I have a lot to pay forward and I would like to contribute to you getting back on board the bike!
Hi there; well it's not so much a ton of money, but I need help w/the wrenching since I now have both hands acting up (3 fingers & several knuckles popping= ouch!) Twiddling a wrench is very difficult. I figure I can schedule a "wrenchday" meet for a holiday or something WHEN I get the garage cleaned up enough to be presentable. I'm too embarrassed to invite peeps here right now. :thumbdown
Here's a list of what I can remember @ 0-dark-thirty in the morning, I have knowledge to do all work except the caliper rebuild (haven't done that), just the friggin' hands are not working. Yes, still getting the run-around from the ortho-doc:
-remove carbs & send them off to Arizona for
free rebuild offer
(only have to pay shipping, he's got all the parts)
-remove tank & clean all the crap out of it
-while I'm at that, need to install a fuel filter so this won't happen again
-remove petcock, replace gaskets/rubber grommet so it don't leak anymore
-while all the top-end stuff is off, should do a valve lash check/adjustment
-pull the front end apart, replace f-tire w/new as it should arrive any day now
(will have to take it to Cycle Gear to get tire mounted/balanced)
-pull front rotors off, & need to find either another used set? or replace both
(been trying to find some of those cheap rotors =$138 a set/no luck yet)
-pull front calipers & rebuild/replace parts= need to order rebuild kit for both
(this could be the cause of rotor warping/ =sticking caliper pots?)
-Should replace pads as the stockers have 15K miles on them but it's cheap
Other things I don't have the $ for: I'm not going to worry about suspension until I'm back aboard & riding, but here's the detail anyway...:
-Steering head bearings need replacing/notch in travel straight ahead
*Suspension: limp as a noodle on both ends, need front end rebuilt, & need
the rear shocks replaced as it's dangerous to ride right now
This is
very expensive= I can ride it like that but it's hella scary! I've been looking for a used set of shocks since I bought it.
*(suspension is approximately $500 for front end rebuild, & the bad one, rear shocks can run anywhere from $500-$1000 (Ohlins/similar high-end shocks are out of the question as too expensive.) Again, I can ride it like that but I have to go slow & be ultra-careful. It's gets chatter right now going straight down the freeway..
that's how bad it is. :thumbdown
These are on me:
Registration + penalties for being couple months late
Insurance (failed to renew, got dropped)
I know I missed some things, but these are the major things to get back on the road. To be safe, I need to do something eventually about the suspension, but sadly it's out of my price range as too expensive. I wouldn't expect any help from anyone on that as its not
necessity items?
Thanks again for all your help...
-ebd